DRASTIC increase in engine noise - pump?

Discussion in 'Gen 2 Prius Care, Maintenance and Troubleshooting' started by 1enigma1, Mar 14, 2010.

  1. 1enigma1

    1enigma1 Junior Member

    Joined:
    May 16, 2005
    10
    0
    0
    Vehicle:
    2005 Prius
    Model:
    N/A
    Not so sure if this is the pump after all, as the discussions on TSB issued prior covering this model (2005) and the audio files uploaded by others do not seem to be similar to the noise I am noting here (though I do think the TSB is applicable to me anyway as I recall hearing the noise a lot this winter).

    That said, I am unsure where the noise is originating from. The basics:

    1. The noise does not seem related to the HVAC system (continues when HVAC is disabled)
    2. The noise does not seem to be related tot he Hybrid drive (when engine is off, the noise is off)
    3. The noise continues after the engine shuts off, but stops shortly after
    4. The noise is at least 5 times louder than the expected noise from the engine - enough to be very noticeable from 30 feet away. In fact, this drowns out the actual engine noise - which is barely audible in the attached recording.

    Really sounds like the coolant pump is about to die, but I am open to suggestions here... I have about 74k miles on the car at this point (a real bummer as if I had known about the TSB, I would have had the pump replaced under warrantee 15k miles ago...).
     

    Attached Files:

    #1 1enigma1, Mar 14, 2010
  2. richard schumacher

    richard schumacher shortbus driver

    Joined:
    Mar 27, 2004
    7,664
    1,042
    0
    Location:
    United States
    Vehicle:
    2004 Prius
    Model:
    N/A
    Yeesh! That almost sounds like something stuck in the cooling fan. With the car OFF take a look. If not I see a trip to a dealer in your near future.
     
    #2 richard schumacher, Mar 15, 2010
  3. northwichita

    northwichita .

    Joined:
    Sep 24, 2006
    481
    102
    29
    Location:
    Wichita KS
    Vehicle:
    2004 Prius
    My guess is the valve train, the vibration is pretty loud, sounds a little like a neighbors lawn mower.

    Whenever I hear strange engine sounds I like to open the hood and check it out, I live on the edge I guess. (Turning on a cold engine, set the heat on high temp, the engine will run until about 140 F is reached before turning off .)

    It is something that should probably be checked out asap.

    Additional way to force an idle from
    http://techno-fandom.org/~hobbit/cars/idle.html
    [SIZE=+1]
    [/SIZE]
     
    #3 northwichita, Mar 15, 2010
  4. hobbit

    hobbit Senior Member

    Joined:
    Mar 23, 2005
    4,089
    468
    0
    Location:
    Bahstahn
    Vehicle:
    2004 Prius
    Model:
    N/A
    NorthW. took the intended words right out of my fingers. Idle
    the sucker, and go up front to try and localize it.
    .
    _H*
     
    #4 hobbit, Mar 16, 2010
  5. 1enigma1

    1enigma1 Junior Member

    Joined:
    May 16, 2005
    10
    0
    0
    Vehicle:
    2005 Prius
    Model:
    N/A
    So, I did localize it better, but the challenge is that it is really behind and below the engine - toward the passenger compartment. By chance does anyone have a diagram of the components in that region? I probably could pick it off of the diagram fairly easily.
     
    #5 1enigma1, Mar 16, 2010
  6. hobbit

    hobbit Senior Member

    Joined:
    Mar 23, 2005
    4,089
    468
    0
    Location:
    Bahstahn
    Vehicle:
    2004 Prius
    Model:
    N/A
    Rattly exhaust heat-shield bolt or other loose piece?
    .
    _H*
     
    #6 hobbit, Mar 17, 2010
  7. 1enigma1

    1enigma1 Junior Member

    Joined:
    May 16, 2005
    10
    0
    0
    Vehicle:
    2005 Prius
    Model:
    N/A
    Well, just got the car back from the shop - got in the next day, fixed same day. Pricy trip, though.
    Turns out I was right the first go around - it ended up being a pump on the way out (and slightly leaking).

    Purrs like a kitten now ;)
     
    #7 1enigma1, Mar 17, 2010
(You must log in or sign up to post here.)