Possible bad transmission? Please help

Discussion in 'Gen 2 Prius Care, Maintenance and Troubleshooting' started by Mike355F1, Mar 25, 2015.

  1. Mike355F1

    Mike355F1 Junior Member

    Joined:
    Nov 18, 2007
    6
    0
    0


    My wife's 2006 Prius is having some problems. The car has 187,000 miles on it. When the engine starts it makes a continuous whirling or humming sound. WHen I try to drive it has minimal power and can not be driven above 15-20 mph on my street. I bought an inexpensive Actron code reader and got the following codes. P0A92 P0300 P0303 P0304 P3191. Does it sound like a definite transmission problem and those other codes are caused by the transmission problem. Any advice you can give is greatly appreciated. Thanks
     
    #1 Mike355F1, Mar 25, 2015
  2. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    111,656
    50,849
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    have the codes read at toyota, or get a mini vci and windows laptop.
     
    #2 bisco, Mar 25, 2015
  3. fuzzy1

    fuzzy1 Senior Member

    Joined:
    Feb 26, 2009
    17,558
    10,334
    90
    Location:
    Western Washington
    Vehicle:
    Other Hybrid
    Model:
    N/A
    Is the gasoline engine even starting at all? Or is it just being spun by the electric MGs without firing?
     
    #3 fuzzy1, Mar 25, 2015
  4. Mike355F1

    Mike355F1 Junior Member

    Joined:
    Nov 18, 2007
    6
    0
    0
    The gasoline engine will start but will cut out and not provide power. Seems the only power is coming from the electric motor
     
    #4 Mike355F1, Mar 25, 2015
  5. Mike355F1

    Mike355F1 Junior Member

    Joined:
    Nov 18, 2007
    6
    0
    0
    Also, the battery is down to one purple bar now
     
    #5 Mike355F1, Mar 25, 2015
  6. fuzzy1

    fuzzy1 Senior Member

    Joined:
    Feb 26, 2009
    17,558
    10,334
    90
    Location:
    Western Washington
    Vehicle:
    Other Hybrid
    Model:
    N/A
    I'm not even close to being an expert on those codes, but from what I found about them, it seems more likely to be a problem with the gas engine (or its fuel or ignition systems) than with the 'transmission' or transaxle.
     
    #6 fuzzy1, Mar 25, 2015
  7. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    111,656
    50,849
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    the battery is low from trying to start the engine, and ev driving. don't take it any lower, or you'll need the special charger to bring it back to life.
     
    #7 bisco, Mar 25, 2015
  8. kenoarto

    kenoarto Senior Member

    Joined:
    Feb 7, 2006
    1,416
    398
    0
    Location:
    Chicago, IL
    Vehicle:
    2005 Prius
    Model:
    II
    How old is the belt?
     
    #8 kenoarto, Mar 25, 2015
  9. Mike355F1

    Mike355F1 Junior Member

    Joined:
    Nov 18, 2007
    6
    0
    0
    The serpentine belt? It is original to the car
     
    #9 Mike355F1, Mar 26, 2015
  10. JC91006

    JC91006 Senior Member

    Joined:
    Nov 10, 2013
    16,642
    8,496
    0
    Location:
    Los Angeles, CA
    Vehicle:
    2008 Prius
    Model:
    II
    1. The belt should have been changed at 100k miles, it drives the water pump which cools the engine.

    Most likely this car is dying from the lack of proper maintenance. If what Fuzzy is saying about the codes being engine related, I would first look into the engine stuff.

    1. spark plugs
    2. clean throttle body
    3. check injectors
    4. make sure engine has oil
    5. make sure the coolant is full (not leaking out from notoriously bad water pump)
     
    #10 JC91006, Mar 26, 2015
  11. Mike355F1

    Mike355F1 Junior Member

    Joined:
    Nov 18, 2007
    6
    0
    0
    The car is maintaned regularly with normal intervaled sythetic oil changes, the coolant has been changed, so has the spark plugs. I will look through the records to see if the belt has been changed and see if I can figure out how to test the injectors. The engine runs fine when it starts. It is my understanding that the transmission being bad could cause the starting/running issues as it is controled by mg1 right?
     
    #11 Mike355F1, Mar 26, 2015
  12. Mike355F1

    Mike355F1 Junior Member

    Joined:
    Nov 18, 2007
    6
    0
    0
    Also I have cleaned the throttle body several times throughout the years
     
    #12 Mike355F1, Mar 26, 2015
  13. kenoarto

    kenoarto Senior Member

    Joined:
    Feb 7, 2006
    1,416
    398
    0
    Location:
    Chicago, IL
    Vehicle:
    2005 Prius
    Model:
    II
    1) Always check the battery first. A low battery causes all kinds of odd stuff and throws wild codes 2) change that old belt immediately
     
    #13 kenoarto, Mar 26, 2015
  14. nh7o

    nh7o Off grid since 1980

    Joined:
    Dec 10, 2011
    1,686
    340
    0
    Location:
    Hawaii
    Vehicle:
    2009 Prius
    Model:
    II
    To the OP: Assuming that the codes you list are accurate (cheap readers can give false codes):
    P0A92 MG1 has a problem (need Techstream to delineate further)
    P0300 P0303 P0304 Misfire (random, and cylinder 3 and 4)
    P3191 Engine does not start (many reasons, like out of gas, or above MG1 problem)

    If you want to DIY this, start by getting the mini VCI referred to above, and getting the INF codes for the DTC's to narrow the cause further. MG1 failures are quite rare, but certainly not unheard of. I don't think the serpentine belt or cooling issues are the root cause here.
     
    #14 nh7o, Mar 26, 2015
  15. JTucson

    JTucson New Member

    Joined:
    Dec 2, 2018
    4
    1
    0
    Location:
    Tucson
    Vehicle:
    2005 Prius
    Model:
    ----USA----
    I have a 2005 Prius that I just took to a shop due to engine noise and not really running well plus tons of lights lit up on the dash. Sounds like some kind of grinding or rubbing noise when the car is running. The shop I went to gave me a code of P0A92-606 and noted I was low on oil as well. Based on your post above could the MG1 be going bad and making noises?" The maintenance history is dodgy on this car and I don't know if its ever had a water pump service on engine or inverter. The car currently has 220,000 miles on the odo. Any thoughts on this would be appreciated.
     
    #15 JTucson, Dec 2, 2018
(You must log in or sign up to post here.)