Recent Content by DoIt

  1. DoIt
    Post

    Traction Battery, from beginning to end

    thanks, revised
    Post by: DoIt, Dec 2, 2021 in forum: Gen 2 Prius Main Forum
  2. DoIt
    Post

    Traction Battery, from beginning to end

    Thanks for the posts all. I've boiled down a step by step for under $100. Hopefully, this gives me at least a 75% probability of success. I...
    Post by: DoIt, Dec 2, 2021 in forum: Gen 2 Prius Main Forum
  3. DoIt
    Post

    Traction Battery, from beginning to end

    Yeh, I've only found 2 40W bulbs so far at home and Walmart was void of incandescent bulbs. We may need explore other methods and am thinking a...
    Post by: DoIt, Nov 30, 2021 in forum: Gen 2 Prius Main Forum
  4. DoIt
    Post

    Traction Battery, from beginning to end

    Albert, it appears that you have 4 bulbs in series. I am assuming that they are 60v bulbs, yielding 240V. While I'm awaiting the HLG-80H-C350A and...
    Post by: DoIt, Nov 29, 2021 in forum: Gen 2 Prius Main Forum
  5. DoIt
    Post

    Traction Battery, from beginning to end

    Thanks for the input / advice. Looked at those prolong grid chargers, bit pricey. Looking at alternatives here and see where an HLG-80H-C350A,...
    Post by: DoIt, Nov 28, 2021 in forum: Gen 2 Prius Main Forum
  6. DoIt
    Post

    Traction Battery, from beginning to end

    Appreciate the advice. The new pack is 1600 and this is an 05 with 250K mi, not sure that makes economic sense. My plan now is to order 1 module...
    Post by: DoIt, Nov 26, 2021 in forum: Gen 2 Prius Main Forum
  7. DoIt
    Post

    Traction Battery, from beginning to end

    Yes, original battery with 240K mi. The scanner not finding codes was the initial autozone scan, which i believe is irrelevant upon Dr. Prius...
    Post by: DoIt, Nov 26, 2021 in forum: Gen 2 Prius Main Forum
  8. DoIt
    Post

    Traction Battery, from beginning to end

    Thanks, hopefully that is all it is. Looking to minimize down time as I'm continuing to drive. To remove battery, clean the posts and busbars, and...
    Post by: DoIt, Nov 26, 2021 in forum: Gen 2 Prius Main Forum
  9. DoIt
    Post

    Traction Battery, from beginning to end

    Typo in initial post, should read 240K miles. Got Dr Prius battery readout, attached. I see #5 block with lower voltage and higher resistance. I...
    Post by: DoIt, Nov 26, 2021 in forum: Gen 2 Prius Main Forum
  10. DoIt
    Post

    Traction Battery, from beginning to end

    Understood, I'll be posting the Dr. Prius scan results, hopefully in a few days. Was tempted to just replace pack with that $1600 pack and skip...
    Post by: DoIt, Nov 21, 2021 in forum: Gen 2 Prius Main Forum
  11. DoIt
    Post

    Traction Battery, from beginning to end

    Primary codes at autozone were P0441 and C1241. The 12V battery checked out OK. These codes have been with me a long time resulting in check...
    Post by: DoIt, Nov 21, 2021 in forum: Gen 2 Prius Main Forum
  12. DoIt
    Thread

    Traction Battery, from beginning to end

    OK, here is the beginning. Got the red triangle and red car with !, and other lights. Autozone scan says loose gas cap, hehe. Traction battery...
    Thread by: DoIt, Nov 21, 2021, 28 replies, in forum: Gen 2 Prius Main Forum
  13. DoIt
    Post

    AC not working, codes 76 and 23

    I just squirted a bunch of refrigerant into the air-filled system and called it good. And it is good and cool.
    Post by: DoIt, Jun 9, 2020 in forum: Gen 2 Prius Care, Maintenance and Troubleshooting
  14. DoIt
    Post

    AC not working, codes 76 and 23

    Just get the compressor already. Got a reman compressor, with oil, on ebay for about 200 and a drier. Was not able to install drier, anyone have...
    Post by: DoIt, Jun 9, 2020 in forum: Gen 2 Prius Care, Maintenance and Troubleshooting